广西顶博发电机组制造

13667715899

添加微信好友了解产品w13667715899

当前位置:首页 > 技术支持

又到暴雨潮湿季节了,广西顶博发电机组制造进水该怎么办?

2021-07-31
来源: 原创
10631
当雨期或台风天鸽季来临时仓库,有能够受洪涝、强降雨等自动地震灾害的印象,因柴油车机发直流无刷电冷水空气能热泵冷水空气能热泵数据中心大部分是在低下室又也可以1楼易被水淹,若发直流无刷电冷水空气能热泵冷水空气能热泵管理防护衣疏忽又也可以任何缘故水有能够从烟管开启打着机缸体。当柴油车机发直流无刷电冷水空气能热泵冷水空气能热泵泡水时,当在启动请完毕停止,并运用有需要的办法,断线外24v电源及蓄電池接驳线,而且检杳各级连接的泡水环境。


When the rainy season or typhoon season comes, it may be affected by natural disasters such as flood and rainstorm. Because the diesel generator set room is generally in the basement or the first floor, it is easy to be flooded. If the generator set is poorly kept and protected or for other reasons, water may enter the engine cylinder from the smoke pipe. When water enters the diesel generator set, if it is running, please shut down immediately, take necessary measures, disconnect the external power supply and battery connection line, and check the water inflow at all parts at the same time.


广西顶博发电机组制造机房


检查广西顶博发电机组制造进水常见问题

1、查检泄压阀管道阀门(排风系统管保底处或消音器器)的出水杆件是否是滴水排尽。Check the exhaust pipe to see if there is water discharged from the drainage component.


2、查看新鲜空气空气油滤表壳可否有内的积水,油滤可否被水浸渍。Check whether there is water in the air filter housing and whether the filter element is immersed in water.


3、查检发电动机组机硬壳底端能不有积液。Check whether there is water accumulated at the bottom of the generator casing.


4、定期检查散热管器、粉丝、连轴器等旋转气缸控制部件是否是赌塞。Check radiator, fan, coupling for blockage.


5、外接要不要有机的油、气油或水的渗漏。Whether there is leakage of organic oil, fuel or water from the outside.


6、卸下来摇背室盖,留意是否是有漏电。捡查发电厂机电机绕线电绝缘/造成的污染实际情况。Remove the rocker chamber cover and observe whether there is water ingress. Check the insulation and ontamination of the generator windings.


7、探测管理电路设计和输出电压电路设计的隔绝。探测管理盖板包块、各仪容仪表、告警安全装置、启动服务器旋转开关。Check the insulation between the control circuit and the output circuit. Check the control panel module, each instrument, alarm device and start switch.


小心:绝对性无法让水破坏汽车发驱动力的熔化室!Note: Never let water enter the combustion chamber of the engine!


浸水处置技巧柴油车火力发同步电冷库机组接触不良后的加工方式:Treatment  after water enter the generator:


当评断静音车风能发主轴电飞机冷库机组发起机的然烧室沒有浸水,绝缘层包含想要时,可重新开机启动静音车风能发主轴电飞机冷库机组。在重新开机启动时要准备以內相关问题:When confirm there is no water in the combustion chamber  and the insulation meets the requirements,can start the generator. Pay attention to the following issues when starting:


1、在加载推动行所有体检,涵盖排卸汽柴油箱积液。电气公司系統逐层上电,观查是否需要有超时。Do all inspections before starting, including draining water in the fuel tank. The electrical system is gradually powered on, and observe whether there is any abnormality.


2、连续不断启用打着机的时段不了已经超过5分钟的英文钟。若打着机不会失火,则体检然油输送管及电力工程漏电开关,1两分钟的英文后在此启用。Start the engine continuously shall not exceed 30 seconds. If the engine cannot catch fire, check the fuel line and electrical circuit, and start again after one or two minutes.


3、捡查发起机歌声有没有发现异常,有没有气味。捡查电气公司仪表盘的界面信息呈现、液晶板界面信息触摸屏有没断屏和界面信息呈现不清。


Check whether the engine sound is abnormal and whether there is a peculiar smell. Check whether the display of the electrical instrument and the LCD screen are broken or unclear.


4、频繁观查柴油汽车机油有压力和水温湿度,若是 汽压或温湿度不相合乎技术工艺规程,应关上打着机。暂停服务后,检查报告每次柴油汽车机油平面图。Closely observe the oil pressure and water temperature. If the oil pressure or temperature does not meet the technical specifications, the engine should be shut down. After stopping, check the oil level.


当来判断打着机可能进水并且没有及时正确地处理、发电站站机绝缘层不一致合规定要求时,切忌未经许可维护,应找寻发电站站制冷机组厂商的专业化科技广西顶博发电机组制造的鼓励。When it is judged that water may enter the engine and the insulation of the generator does not meet the requirements, do not repair it without authorization, and seek the help of professional technicians from the generator manufacturer.


雷暴/会很潮湿区域环境,静音风能发三相电汽轮柴油广西顶博发电机组制造使用的要注意关键环节Key points for unit operation in rainstorm / humid environment


1、码放环境规定要求1. Placement environment requirements(1)野外置放安全使用的冷水机组,需制作好防雨罩布处理,调试防雨罩布棚、隔音箱等;


Rainproof measures shall be taken for units placed outdoors, and rainproof sheds, static speakers, etc. shall be equipped;


(2)空气能热泵金属外壳须有可靠性的保护好跨接线,对都要有弱酸性点可以直接跨接线的生产发无刷电机,则务必由非常专业技术人员做好弱酸性跨接线;The shell of the unit must be reliably grounded. For generators requiring direct neutral grounding, the neutral grounding must be carried out by professionals;


(3)电雷多见的地区用机械,请配备防雷传动装置。If machines are used in lightning prone areas, please configure lightning protection devices.


(4)请不可将空气能热泵机组放上于地形较低,楼基不牢(泥土等脏东西地面的)最易的积水情况的地区;Please do not place the unit in a place with low terrain, weak foundation (soil ground) and easy to accumulate water;


(5)搭建在地下通道水室选择的刷卡机,需加强地下通道水室引流、地下室防潮上班。For machines placed in the basement, drainage and moisture-proof work in the basement shall be done well.
举荐好的文章
柴油发电机厂家 柴油发电机厂家 柴油发电机厂家 柴油发电机厂家 柴油发电机厂家